为明确钻爆法施工爆破后隧道的粉尘与有害气体分布情况,检验通风、防尘效果,分别利用风速仪、粉尘仪和气体检测仪对兰渝铁路四座高瓦斯隧道的风速、粉尘和有害气体进行现场测试。测试结果显示:穿山甲风机配合螺旋式风管的压入式通风的效果最好,采用这种配置通风20 min左右,掌子面附近的粉尘、SO2等有害气体浓度即降至允许浓度以下,通风30 min左右CO浓度降至允许浓度以下。隧道内风速主要受断面大小、掘进长度和通风设备及其维护等影响,隧道断面对净化空气所需要的通风时间影响最大,风管漏风率次之,再次为通风长度。在确保设备维护和通风管理情况下,穿山甲风机高档配合螺旋风管可实现长距离通风。
Abstract
To find out the distribution of dust and harmful gases and check the effect of ventilation and dust prevention after blasting in tunnel construction with the drilling and blasting method, the wind velocity, dust concentration and the concentration of harmful gases inside the four high gas tunnels of Lanzhou-Chongqing Railway were tested by using anemometers, dust monitor and gas detector respectively. The results of these field tests show that: there is the best ventilation effect by forced ventilation with the“Pangolin” fans and the spiral duct. After ventilating with this configuration about 20 min, the content of dust and SO2 near the working face fell below the allowable concentration, then the content of CO dropped below the allowable concentration about 30 min of ventilation. The wind velocity inside the tunnels is mainly affected by the cross-section size, length of excavation and ventilation equipment and its maintenance. The greatest impact on the ventilating time needed to purify the tunnel air is the cross-section size and followed by the air leakage rate, then the ventilation length. So, on the condition of good equipment maintenance and ventilating management, a long distance ventilation can be achieved.
关键词
施工通风 /
现场测试 /
粉尘 /
有害气体 /
隧道施工
{{custom_keyword}} /
Key words
construction ventilation /
field test /
dust /
harmful gases /
tunnel construction
{{custom_keyword}} /
中图分类号：
U453.5
{{custom_clc.code}}
({{custom_clc.text}})
{{custom_sec.title}}
{{custom_sec.title}}
{{custom_sec.content}}
参考文献
[1] 陈万忠.秦岭终南山特长公路隧道施工技术研究[D].成都:西南交通大学,2006. (Chen Wanzhong. Technical study on the construction method applied for Zhongnanshan Extra-Longer Tunnel in Qinling Mountain[D]. Chengdu: Southwest Jiaotong University, 2006. (in Chinese))
[2] 陶坤.压入式通风在隧道施工中的动态设计与应用分析[J].公路交通科技(应用技术版),2008,(6):168-171. (Tao Kun. Forced ventilation dynamic design and application analysis in construction of tunnel[J]. Journal of Highway and Transportation Research and Development (Application Technology Edition), 2008, (6):168-171. (in Chinese))
[3] 江亦元,王梦恕,王星华,等.高原多年冻土隧道施工技术及方案研究[J].铁道学报,2006,28(2):67-73. (Jiang Yiyuan, Wang Mengshu, Wang Xinghua, et al. Research on construction technology and plans of tunnels in the plateau permafrost region[J]. Journal of the China Railway Society, 2006, 28(2): 67-73. (in Chinese))
[4] 曾艳华,何川.斜井送排式通风隧道的火灾救援通风研究[J].防灾减灾工程学报,2009,29(2):219-223. (Zeng Yanhua, He Chuan. Research on rescue ventilation in highway tunnel with air exchange shaft [J]. Journal of Disaster Prevention and Mitigation Engineering, 2009, 29(2): 219-223. (in Chinese))
[5] 任锐,谢永利,楼慧元.半横向通风方式隧道内污染物分布的数值仿真[J].防灾减灾工程学报,2011,31(1):96-101. (Ren Rui, Xie Yongli, Lou Huiyuan. Numerical simulation and engineering applications of pollutant distribution inside the tunnel with semi-transverse ventilation system [J]. Journal of Disaster Prevention and Mitigation Engineering, 2011, 31(1): 96-101. (in Chinese))
[6] 邱维军.太行山隧道1号斜井及正洞独头压入式通风技术[J].铁道标准设计,2007(4):41-43. (Qiu Weijun. Independent head with forced ventilation technology on the 1st inclined shaft of the Taihang Mountain Tunnel and the main tunnel [J]. Railway Standard Design, 2007(4):41-43. (in Chinese))
[7] 陈琳.公路隧道无轨运输条件下长距离施工通风技术[J].铁道建筑,2011(8):33-35. (Chen Lin. Long-distance construction ventilation technology of trackless transport of highway tunnel[J]. Railway Engineering, 2011(8): 33-35. (in Chinese))
[8] 施红生,赵亚林,任安绚.电气化隧道内有害气体污染的监测评价模式研究[J].中国铁道科学,2002,23(1):128-132. (Shi Hongsheng, Zhao Yalin, Ren Anxun. Study on assessment mode for monitoring harmful gas pollution in long tunnel on electrified railway [J]. China Railway Science, 2002, 23(1): 128-132. (in Chinese))
[9] 危宁,李力,王春燕.隧道施工通风中的有害气体浓度变化分析[J].三峡大学学报(自然科学版),2006, 28(4):324-327. (Wei Ning, Li Li, Wang Chunyan. Analysis of harmful gas concentration variation in tunneling ventilation [J]. Journal of China Three Gorges University (Natural Sciences), 2006, 28(4): 324-327. (in Chinese))
[10]刘钊春,柴军瑞,贾晓梅,等.压入式通风掘进面有害气体浓度扩散数值模拟[J].岩土力学.2009,30(增2):536-539. (Liu Zhaochun, Chai Junrui, Jia Xiaomei, et al. Numerical simulation of concentration diffusion of harmful gas in heading face with forced ventilation [J]. Rock and Soil Mechanics, 2009, 30(Supp.2): 536-539. (in Chinese))
[11]谭信荣,陈寿根,张恒.基于洞内空气质量测试的长大隧道施工通风优化[J].现代隧道技术,2012,49(6):152-157. (Tan Xinrong, Chen Shougen, Zhang Heng. Ventilation optimization at big and long tunnel construction based on the air quality testing [J]. Modern Tunneling Technology, 2012, 49(6): 152-157. (in Chinese))
[12]谭信荣,陈寿根,马辉.空气质量测试在长大隧道施工中的应用[J].安全与环境学报,2012,12(6):103-107. (Tan Xinrong, Chen Shougen, Ma Hui. Application of air quality measuring in big and long tunnel construction [J]. Journal of Safety and Environment, 2012, 12(6): 103-107. (in Chinese))
{{custom_fnGroup.title_cn}}
脚注
{{custom_fn.content}}
PDF(1866 KB)
