Research on the Application of Load Distribution Type Composite Anchors in Layered Soil and Rock Massn

  • Liu Yuguo ,
  • Xia Kai ,
  • Zhang Mingli ,
  • Zhang Xin ,
  • Ma Yanqing
Expand
  • 1. China Construction Fourth Engineering Bureau Co., Ltd., Guangzhou 510000, P.R. China;
    2. Key Laboratory of Disaster Prevention and Mitigation in Civil Engineering of Gansu Province, Lanzhou University of Technology, Lanzhou 730050, P.R. China

Received date: 2024-04-20

  Online published: 2025-03-12

Abstract

The strength stratification of the rock and soil mass results in different ultimate bearing capacities for each segment of the anchor rod, leading to a reduction in the anchoring effect. A load-sharing composite anchor rod was designed for an in-situ test in a deep foundation pit where the strength of weathered mudstone was stratified due to the influence of underground water seepage. The results indicate that: (1)The bearing capacity of load-distributed composite anchor rods is more than 1.52 times higher than that of tension-only anchor rods of the same length, and is more than 1.13 times higher than that of load-dispersed composite anchor rods of the same length. Thus, the bearing capacity of the anchor rods has been further improved. (2)After immersion in water, the second interface shear strength of the anchor rods in moderately weathered mudstone is reduced by up to 66%, resulting in different ultimate bearing capacities of the anchor rod units. This affects the transfer and distribution of loads within the anchor rod sections. (3)The load distribution composite anchor rod ensures that each unit anchoring section carries a load close to its ultimate bearing capacity, achieving the goal of proportional distribution of anchor head loads based on the ultimate bearing capacity of each unit anchoring section.(4)By proportionally distributing the anchor head load, the structural ductility of the anchor rod is enhanced, effectively avoiding premature failure of the anchor rod at weak points. At the same time, this can also prevent the occurrence of cracks between the unit anchoring sections during the loading process. Therefore, the service life of the anchor rod is extended. (5)The load distribution composite anchor rod can provide internal support to the rock within the anchoring section, effectively improving the stability and load-bearing capacity of the surrounding rock mass. This helps prevent the occurrence of geological disasters such as rock burst and collapse, ensuring the safety and reliability of engineering structures. Additionally, the load distribution composite anchor rod can also effectively control the deformation and displacement of the surrounding rock, minimizing the impact on surrounding structures.

Cite this article

Liu Yuguo , Xia Kai , Zhang Mingli , Zhang Xin , Ma Yanqing . Research on the Application of Load Distribution Type Composite Anchors in Layered Soil and Rock Massn[J]. Chinese Journal of Underground Space and Engineering, 2025 , 21(1) : 272 -282 . DOI: 10.20174/j.JUSE.2025.01.30

References

[1] 何满潮, 钱七虎. 深部岩体力学基础[M]. 北京: 科学出版社, 2010. (He Manchao, Qian Qihu. The basis of deep rock mechanics[M]. Beijing: Science Press, 2010. (in Chinese))
[2] 程良奎. 岩土锚固的现状与发展[J]. 土木工程学报, 2001, 34(3): 7-12, 34. (Cheng Liangkui. Present status and development of ground anchorages[J]. China Civil Engineering Journal, 2001, 34(3): 7-12, 34. (in Chinese))
[3] 丁瑜, 王全才, 何思明. 拉力分散型锚索锚固段荷载传递机制[J]. 岩土力学, 2010, 31(2): 599-603. (Ding Yu, Wang Quancai, He Siming. Loading transfer mechanism of dispersion-type tensile cables along anchoring section[J]. Rock and Soil Mechanics, 2010, 31(2): 599-603. (in Chinese))
[4] Yang S, Zhu X G, Zhang G F, et al. Research on the mechanics performance of the new tension-compression rock bolt through numerical simulation[J]. Geotechnical and Geological Engineering, 2022,40(4): 2255-2266.
[5] 刘小斌, 李兆锋, 泰培, 等. 拉力型锚杆锚固体应力分布规律的现场试验研究[J]. 地下空间与工程学报, 2021, 17(增1): 63-70. (Liu Xiaobin, Li Zhaofeng, Tai Pei, et al. In-situ experimental investigation on stress distribution of grout body of tension-type ground anchor[J]. Chinese Journal of Underground Space and Engineering, 2021, 17(Supp.1):63-70. (in Chinese))
[6] Öser C, & Sayin B. Geotechnical assessment and rehabilitation of retaining structures collapsed partially due to environmental effects[J]. Engineering Failure Analysis, 2021, 119: 104998.
[7] 耿冬青, 程学军, 宋福渊, 等. 压力分散型锚杆在某基础抗浮工程中的应用[J]. 建筑结构学报, 2005, 26(1): 119-124. (Geng Dongqing, Cheng Xuejun, Song Fuyuan, et al. The application of dispersed pressure anchor in a permanent anti-floating project[J]. Journal of Building Structures, 2005, 26(1): 119-124. (in Chinese))
[8] 刘鸿, 周德培, 王志斌. 压力分散型锚索锚固机制模型试验研究[J]. 岩石力学与工程学报, 2012, 31(增1): 3075-3081. (Liu Hong, Zhou Depei, Wang Zhibin. Model test study of anchoring and reinforcing mechanism of pressure diffusion anchor cable[J]. Chinese Journal of Rock Mechanics and Engineering, 2012, 31(Supp.1): 3075-3081. (in Chinese))
[9] 吴曙光, 付红梅, 张岩岩. 拉压分散型锚索锚固机制及工程应用研究[J]. 岩土力学, 2018, 39(6): 2155-2163, 2174. (Wu Shuguang, Fu Hongmei, Zhang Yanyan. Study on anchorage mechanism and application of tension-compression dispersive anchor cable[J]. Rock and Soil Mechanics, 2018, 39(6): 2155-2163, 2174. (in Chinese))
[10] 涂兵雄, 蔡燕燕, 何锦芳, 等. 新型拉压复合型锚杆锚固性能研究Ⅲ:现场试验[J]. 岩土工程学报, 2019, 41(5): 846-854. (Tu Binxiong, Cai Yanyan, He Jinfang, et al. Analysis of anchorage performance on new tension-compression anchor Ⅲ field test[J]. Chinese Journal of Geotechnical Engineering, 2019, 41(5): 846-854. (in Chinese))
[11] 韩军, 陈强, 刘元坤, 等. 锚杆灌浆体与岩(土)体间的粘结强度[J]. 岩石力学与工程学报, 2005, 24(19): 84-88. (Han Jun, Chen Qiang, Liu Yuankun, et al. Bond strength between anchor grout and rock or soil masses[J]. Chinese Journal of Rock Mechanics and Engineering, 2005, 24(19): 84-88. (in Chinese))
[12] 靖洪文, 苏海健, 孟波, 等. 巷道锚杆锚固力学特性现场试验研究[J]. 中国矿业大学学报, 2022, 51(1): 16-23. (Jing Hongwen, Su Haijian, Meng Bo, et al. Field test research on anchorage mechanical characteristics of roadway bolt[J]. Jounal of China University of Ming & Technology, 2022, 51(1): 16-23. (in Chinese))
[13] 曹羽哲. 广东韶关甘棠滑坡破坏概率分析及稳定性研究[D]. 湘潭: 湖南科技大学, 2021. (CAO Yuzhe. Failure probability analysis and stability study of Gantang landslide in Shaoguan, Guangdong[D]. Xiangtan: Hunan University of Science and Technology, 2021. (in Chinese))
[14] 翟越, 宗燕燕, 侯亚楠, 等. 城市地下空间全寿命风险分析与防控体系构建[J]. 地学前缘, 2019, 26(3): 95-103. (Zhai Yue, Zong Yanyan, Hou Yanan, et al. Whole life-cycle risk analysis and construction of prevention and control system for underground space[J]. Earth Science Frontiers, 2019, 26(3): 95-103. (in Chinese))
[15] 张治国, 毛敏东, Pany T, 等. 隧道-滑坡相互作用影响及控制防护技术研究现状与展望[J]. 岩土力学, 2021, 42(11): 3101-3125. (Zhang Zhiguo, Mao Mindong, Pany T, et al. Research status and prospect of tunnel-landslide interaction and control protection technology[J]. Rock and Soil Mechanics, 2021, 42(11): 3101-3125. (in Chinese))
[16] 柳万里, 晏鄂川, 戴航, 等. 巴东组泥岩水作用的特征强度及其能量演化规律研究[J]. 岩石力学与工程学报, 2020, 39(2): 311-326. (Liu Wanli, Yan Echuan, Dai Hang, et al. Study on characteristic strength and energy evolution law of Badong formation mudstone under water effect[J]. Chinese Journal of Rock Mechanics and Engineering, 2020, 39(2): 311-326. (in Chinese))
[17] 朱江鸿, 余荣光, 韩淑娴, 等. 干湿循环下不同初始干密度泥岩强度劣化研究[J]. 铁道学报, 2021, 43(10): 109-117. (Zhu Jianghong, Yu Rongguang, Han Shuxian, et al. Strength deterioration of mudstone with different initial dry densities under dry-wet cycles [J]. Journal of the China Railway Society, 2021, 43(10): 109-117. (in Chinese))
[18] Xu Y, Liao X, Li J, et al. The effects of water content and dry-wet cycles of weak-interlayer soil on stability of clastic rock slope[J]. Geotechnical and Geological Engineering volume, 2021, 39(5): 3753-3760.
[19] Liu J, Xu Q, Wang S, et al. Formation and chemo-mechanical characteristics of weak clay interlayers between alternative mudstone and sandstone sequence of gently inclined landslides in Nanjiang, SW China[J]. Bulletin of Engineering Geology and the Environment, 2020, 79(9): 4701-4715.
[20] 张玲, 赵明华, 赵衡. 倾斜荷载下桩柱式桥墩受力变形分析传递矩阵法[J]. 中国公路学报, 2015, 28(2): 69-76. (Zhang Ling, Zhao Minghua, Zhao Heng. Transfer matrix method for deformation of pile type bridge pier under axial transverse load[J]. China Journal of Highway and Transport, 2015, 28(2): 69-76. (in Chinese))
[21] 樊亚龙. 盐渍土环境下GFRP复合桩竖向承载性能及耐久性研究[D]. 开封: 河南大学, 2022. (Fan Yalong. Research on vertical bearing performance and durability of GFRP composite piles in saline soil environment[D]. Kaifeng: Henan University, 2022. (in Chinese))
[22] 王文博. 随钻跟管桩抗震性能的振动台试验和数值分析[D]. 广州: 广州大学, 2022. (Wang Wenbo. Shaking table test and numerical analysis of seismic performance of drilling with prestressed concrete pipes[D]. Guangzhou: Guangzhou University, 2022. (in Chinese))
[23] 周子舟, 杨素春, 李伟. 拉力分散型锚杆应力分布特性对比试验研究[J]. 工程勘察, 2016, 44(11): 14-18, 73. (Zhou Zizhou, Yang Suchun, Li Wei. Comparative experimental study on axial force distribution of tension dispersed anchor[J]. Geotechnical Investigation & Surveying, 2016, 44(11): 14-18, 73. (in Chinese))
[24] 夏小兵, 夏凯, 刑领, 等. 一种分层岩土压拉组合锚杆[P]. 中国专利:ZL202121752372.1, 2022-01-25. (Xia Xiaobing, Xia Kai, Xing Ling, et al. A layered rock-soil compression-tension combined anchor[P]. China Paternt: ZL202121752372.1, 2022-01-25. (in Chinese))
[25] 汪班桥, 门玉明, 郝建斌. 拉压锚杆锚固性能的对比试验分析[J]. 长安大学学报(自然科学版), 2013, 33(4): 68-74. (Wang Banqiao, Men Yuming, Hao Jianbing. Experiment and analysis of anchorage performances of pressure type and tensile type anchor[J]. Journal of Chang’an University ( Natural Science Edition ), 2013, 33(4): 68-74. (in Chinese))
[26] 曹雪山, 额力素, 赖喜阳, 等. 崩解泥化过程中泥岩强度衰减因素研究[J]. 岩土工程学报, 2019, 41(10): 1936-1942. (Cao Xueshan, E Lisu, Lai Xiyang, et al. Factors for strength attenuation of mudstone during slaking and disintegration[J]. Chinese Journal of Geotechnical Engineering, 2019, 41(10): 1936-1942. (in Chinese))
[27] 中国建筑科学研究院. 建筑基坑支护技术规程(JGJ 120—2012)[S]. 北京: 中国建筑工业出版社, 2012. (China Academy of Building Research. Technial specification for retaining and protection of building foundation excavations[S]. Beijing: China Architecture & Building Press, 2012. (in Chinese))
[28] 中冶集团建筑研究总院. 岩土锚杆(索)技术规程(CECS22—2018)[S]. 北京: 中国计划出版社, 2018. (China Metallurgical Group Building Research Institute. Technical specification for rock and soil anchor (cable)[S]. Beijing: China Planning Press, 2018. (in Chinese))
[29] 白晓宇, 张明义, 闫楠. 两种不同材质抗浮锚杆锚固性能的现场对比试验研究与机理分析[J]. 土木工程学报, 2015, 48(8): 38-46, 59. (Bai Xiaoyu, Zhang Mingyi, Yan Nan. Field contrast test and mechanism analysis on anchorage performance of anti-floating anchors with two different materials[J]. China Civil Engineering Journal, 2015, 48(8): 38-46, 59. (in Chinese))
[30] 贾金青, 涂兵雄, 王海涛, 等. 压力分散型预应力锚杆的力学机理研究[J]. 岩土工程学报, 2011, 33(9): 1320-1325. (Jia Jinqing, Tu Binxiong, Wang Haitao, et al. Mechanical behaviors of pressure-dispersive prestressed anchor[J]. Chinese Journal of Geotechnical Engineering, 2011, 33(9): 1320-1325. (in Chinese))
Outlines

/