理论与试验研究

粉煤灰改良红层泥岩填料静三轴试验研究

  • 余云燕 ,
  • 丁小刚 ,
  • 黄志勤
展开
  • 兰州交通大学 土木工程学院,兰州 730070
余云燕(1968—),女,浙江江山人,博士,教授,主要从事岩土力学、土与结构耦合动力学方面的研究。E-mail: yuyunyan@mail.lzjtu.cn

收稿日期: 2023-10-16

  网络出版日期: 2024-07-15

基金资助

甘肃省科技计划(21YF5GA050);甘肃省教育厅产业支撑计划项目(2021CYZC-28);甘肃省交通运输厅科技研发项目(2021-12);甘肃省基础研究创新群体项目(21JR7RA347)

Experimental Study on Static Triaxial Test of Fly Ash Modified Red Mudstone Filler

  • Yu Yunyan ,
  • Ding Xiaogang ,
  • Huang Zhiqin
Expand
  • School of Civil Engineering, Lanzhou Jiaotong University, Lanzhou 730070, P.R. China

Received date: 2023-10-16

  Online published: 2024-07-15

摘要

红层泥岩的吸水软化和体积膨胀特性易造成路基翻浆冒泥现象及路基不均匀沉降等病害,在作为公路路基填料时应对其进行改良。本文选用粉煤灰作为改良剂,通过室内X射线衍射试验、化学成分测试和易溶盐等试验,分析红层泥岩和粉煤灰的成分组成及离子含量;通过无侧限抗压强度试验、室内变水头渗透试验和固结等试验分析了试样改良前后物理力学特性;通过常规三轴UU试验,研究了不同粉煤灰掺量对改良试样剪切应力-应变及抗剪强度的影响;分析了粉煤灰掺量为10%时,养护龄期对改良试验抗剪强度参数的影响。结果表明:该地区红层泥岩属低液限黏土,其易溶盐溶液中的SO42-离子含量最高,pH值呈碱性;三轴剪切试验中,改良和未改良试样均呈塑性破坏,试样粉煤灰掺量和龄期均对试样抗剪强度提高具有促进作用,且黏聚力增长幅度远大于内摩擦角;粉煤灰掺量为10%龄期28 d时,试样黏聚力较未改良未养护试样和10%掺量未养护试样分别提升37.9%和6.9%,内摩擦角分别增大了1.2°和0.7°。试样的静力学试验均验证了粉煤灰改良的可靠性。

本文引用格式

余云燕 , 丁小刚 , 黄志勤 . 粉煤灰改良红层泥岩填料静三轴试验研究[J]. 地下空间与工程学报, 2024 , 20(3) : 838 -847 . DOI: 10.20174/j.JUSE.2024.03.13

Abstract

The water absorption and softening and volume expansion characteristics of the red mudstone are prone to cause the phenomenon of slurry mud and uneven settlement of the roadbed and other diseases, so it should be improved when used as highway roadbed filler. In this paper, fly ash was chosen as an improver to analyze the compositional composition and ionic content of red-bedded mudstone and fly ash through indoor X-ray diffraction tests, chemical composition tests and easily soluble salts. The physical and mechanical properties of the specimens before and after improvement were analyzed by unconfined compressive strength tests, indoor variable head penetration tests and consolidation tests. The effects of different fly ash admixtures on the shear stress-strain gauge shear strength of the modified specimens were investigated by conventional triaxial UU tests; the effects of the age of maintenance on the shear strength parameters of the modified tests when the fly ash admixture was 10% were analyzed. The results show that the red mudstone in the area is a low liquid-limit clay with the highest SO42- ion content and alkaline pH in its labile salt solution. In triaxial shear test, both modified and unmodified specimens showed plastic damage, and both the amount and age of fly ash admixture of the specimens contributed to the increase of shear strength of the specimens, and the increase of cohesion was much larger than the internal friction angle. The cohesive force of the specimens at the age of 28 d with 10% fly ash was 37.9% and 6.9% higher than that of the unmodified unmaintained specimens and 10% unmaintained specimens, respectively, and the internal friction angle increased by 1.2° and 0.7°. The hydrostatic experiments of the specimens all verified the reliability of the fly ash improvement.

参考文献

[1]许强,唐然.红层及其地质灾害研究[J].岩石力学与工程学报,2023,42(1):28-50.(Xu Qiang, Tang Ran. Study on red beds and its geological hazards[J]. Chinese Journal of Rock Mechanics and Engineering, 2023, 42(1): 28-50. (in Chinese))
[2]程强,寇小兵,黄绍槟,等.中国红层的分布及地质环境特征[J].工程地质学报,2004 (1):34-40. (Cheng Qiang, Kou Xiaobing, Huang Shaobin, et al. The Distribution and geological environment characteristics of red beds in China[J]. Journal of Engineering Geology, 2004 (1): 34-40. (in Chinese))
[3]柳群义.红层路堑边坡稳定性与防治研究[D].长沙:中南大学,2010.( Liu Qunyi. Study on the stability of road slope with red bedded rock mass and its reinforcement technique[D]. Changsha: Central South University, 2010. (in Chinese))
[4]毕海民, 祁凤祥. 粉煤灰混合聚丙烯纤维改良膨胀土性能试验研究[J]. 粉煤灰综合利用, 2018 (3): 62-64. (Bi Haimin, Qi Fengxiang. Study on the performance test of the modified expansive soil by fly ash mixed polypropylene fiber[J]. Fly Ash Comprehensive Utilization, 2018 (3): 62-64. (in Chinese))
[5]郭永春,谢强,文江泉.我国红层分布特征及主要工程地质问题[J]. 水文地质工程地质,2007(6):67-71. (Guo Yongchun, Xie Qiang, Wen Jiangquan. Red beds distribution and engineering geological problem in China[J]. Hydrogeology and Engineering Geology, 2007(6): 67-71. (in Chinese))
[6]冯美果,陈善雄,余颂,等.粉煤灰改性膨胀土水稳定性试验研究[J].岩土力学,2007,28(9):1889-1893.(Feng Meiguo, Chen Shanxiong, Yu Song, et al. Laboratory study on water stability of flyash-treated expansive soil[J].Rock and Soil Mechanics,2007,28(9): 1889-1893.(in Chinese))
[7]郑江, 舒海明, 但汉成. 软岩改良土无侧限抗压强度试验研究[J]. 铁道工程学报, 2009, 26(7): 94-97, 106. (Zheng Jiang, Shu Haiming, Dan Hancheng. Indoor experimental research on the unconfined compressive strength of modified soft soil [J]. Journal of Railway Engineering Society, 2009, 26(7): 94-97, 106. (in Chinese))
[8]Michael Edward botts. The effects of slaking on the engineering behavior of clay shales[D]. Graduate school of the university of Colorado, 1986.
[9]杨峰峰,张巨峰,郑超,等.基于分形原理的红层软岩崩解特性试验研究[J].应用力学学报,2022,39(2):350-355. (Yang Fengfeng, Zhang Jufeng, Zheng Chao, et al. Experimental study on disintegration characteristics of red bed soft rock based on fractal principle[J]. Chinese Journal of Applied Mechanics, 2022,39(2): 350-355. (in Chinese))
[10]周翠英,刘镇,薛翊国,等.关于红层灾变基础研究的若干思考[J].工程地质学报,2023,31(3):689-705.(Zhou Cuiying, Liu Zhen, Xue Yiguo, et al. Some thoughts on basic research of red beds disaster[J]. Journal of Engineering Geology, 2023,31 (3) : 689-705. (in Chinese))
[11]蒋关鲁, 房立凤, 王智猛, 等. 红层泥岩路基填料动强度和累积变形特性试验研究[J]. 岩土工程学报, 2010, 32(1): 124-129. (Jiang Guanlu, Fang Lifeng, Wang Zhimeng, et al. Experimental study on dynamic strength and accumulated deformation characteristics of red-mudstone filling[J]. Chinese Journal of Geotechnical Engineering, 2010, 32(1): 124-129. (in Chinese))
[12]冯强. 四川红层泥岩的分布及其路用性能研究[D]. 成都: 西南交通大学, 2011. (Feng Qiang. Distribution of red-layered mudstone in Sichuan and its road performance[D]. Chengdu: Southwest Jiaotong University, 2011. (in Chinese))
[13]王鹏, 余云燕, 包得祥. 甘肃红层泥岩填料物理力学特性的试验研究[J]. 硅酸盐通报, 2019, 38(2): 522-529. (Wang Peng, Yu Yunyan, Bao Dexiang. Experimental study on physical and mechanical properties of red-mudstone filling in Gansu[J]. Bulletin of the Chinese Ceramic Society, 2019, 38(2): 522-529. (in Chinese))
[14]余云燕, 罗崇亮, 包得祥, 等. 兰州地区红层泥岩物理力学特性试验[J]. 兰州交通大学学报, 2019, 38(5): 1-6. (Yu Yunyan, Luo Chongliang, Bao Dexiang, et al. Experimental study on physical and mechanical properties of red mudstone in Lanzhou area [J]. Journal of Lanzhou Jiaotong University, 2019, 38(5): 1-6. (in Chinese))
[15]黄志勤,余云燕.粉煤灰改良红层填料物理力学特性研究[J].科技与创新,2022(20):21-23. (Huang zhiqin, Yu Yunyan. Study on physical and mechanical properties of fly ash modified red layer filler[J]. Science and Technology and Innovation,2022(20):21-23. (in Chinese))
[16]罗崇亮,余云燕,包得祥,等.基于三轴试验红层泥岩的邓肯-张模型参数研究[J].地震工程学报,2019,41(2):436-444. (Luo Chongliang, Yu Yunyan, Bao Dexiang, et al. Duncan-Zhang model parameters of red mudstone based on triaxial tests [J]. China Earthquake Engineering Journal, 2019, 41 (2): 436-444. (in Chinese))
[17]孔祥辉,蒋关鲁.循环荷载下红层泥岩土累积变形特性[J].长江科学院院报,2012,29(12):68-72, 77. (Kong Xianghui, Jiang Guanlu. Cumulative deformation characteristics of red mudstone soil under cyclic loading [J]. Journal of Changjiang River Scientific Research Institute, 2012,29 (12): 68-72, 77. (in Chinese))
[18]陈康,刘先峰,袁胜洋,等.饱和红层泥岩填料累积变形特性及安定界限研究[J].岩土力学,2022,43(5):1261-1268. (Chen Kang, Liu Xianfeng, Yuan Shengyang, et al. Experimental study of accumulative deformation behaviour and shakedown limit of saturated red mudstone fill material[J]. Rock and Soil Mechanics, 2022,43(5):1261-1268. (in Chinese))
[19]Kamon M, Gu H, Masahiro I. Improvement of mechanical properties of ferrum lime stabilized soil with the addition of aluminum sludge[J]. Journal of the Society of Materials Science Japan, 2009, 50(3):47-53.
[20]高曙光, 高晖, 肖尊群. 某高速公路红层泥岩路基填料改良试验研究[J]. 路基工程, 2018, 22(3): 107-112. (Gao Shuguang, Gao Hui, Xiao Zunqun. Experimental study on improvement of red mudstone subgrade filler on an expressway [J]. Subgrade Engineering, 2018, 22(3): 107-112. (in Chinese))
[21]祝艳波, 余宏明, 杨艳霞, 等. 红层泥岩改良土特性室内试验研究[J]. 岩石力学与工程学报, 2013, 32(2): 425-432. (Zhu Yanbo, Yu Hongming, Yang Yanxia, et al. Indoor experimental research on characteristic of improved red-mudstone [J]. Chinese Journal of Rock Mechanics and Engineering, 2013, 32(2): 425-432. (in Chinese))
[22]熊力. 红层软岩崩解机理研究及工程应用[D].长沙:湖南大学,2011. (Xiong Li. Research on the mechanism of red-bedded soft rock disintegration and engineering application[D]. Changsha: Hunan University, 2011. (in Chinese))
[23]交通运输部公路科学研究院.公路土工试验规程(JTG 3430—2020)[S].北京:人民交通出版社,2020. (Highway Science Research Institute, Ministry of Transport. Test methods of soils for highway engineering (JTG 3430—2020) [S]. Beijing: China Communications Press,2020. (in Chinese))
[24]中华人民共和国住房和城乡建设部.盐渍土地区建筑技术规范(GB/T50942—2014) [S].北京:中国计划出版社, 2015. (Ministry of Housing and Urban-Rural Development of the People's Republic of China. Technical code for building in saline soil regions (GB/T50942—2014)[S]. Beijing: China Planning Press, 2015. (in Chinese))
[25]张桂荣, 罗紫婧, 邵勇, 等. 水泥、粉煤灰改良细砂土的工程特性与改良机理[J]. 水利与建筑工程学报, 2019, 17(5): 128-132.(Zhang Guirong, Luo Zijing, Shao Yong, et al. Engineering characteristics and improvement mechanism of fine sand improved by cement and fly ash[J]. Journal of Water Resources and Architectural Engineering, 2019, 17(5): 128-132. (in Chinese))
文章导航

/